Common Replacement Parts
Most Frequently Replaced Parts:
- Spray Arms (Upper and Lower)
- Door Latch Assembly
- Heating Element
- Water Inlet Valve
- Drain Pump
- Door Gasket/Seal
- Filter Assembly
- Rack Rollers
Part Numbers & Descriptions
| Upper Spray Arm | 00645194 |
| Lower Spray Arm | 00611925 |
| Heating Element | 00645170 |
| Door Latch Assembly | 00654252 |
| Water Inlet Valve | 00645051 |
| Drain Pump | 00645079 |
| Door Gasket | 00654260 |
| Filter Assembly | 00654245 |
Technical Specifications
| Model Number | SHX68T52UC/02 |
| Type | Built-in Dishwasher |
| Color | Stainless Steel |
| Place Settings | 16 Place Settings |
| Noise Level | 42 dB |
| Control Type | Electronic Touch Controls |
| Energy Rating | Energy Star Certified |
| Water Consumption | 2.9 Gallons per Cycle |
| Power Requirements | 120V, 60Hz, 15A |
| Dimensions (HxWxD) | 33.875 x 23.5625 x 23.5625 inches |
| Weight | 105 lbs |
Warranty Information
- Full Warranty: 1 year parts and labor
- Extended Warranty: 5 years on tub and door liner
- Parts Warranty: 90 days on replacement parts
For warranty service, contact Bosch Customer Service at 1-800-944-2904 or visit Bosch-Home.com
Parts Installation Guide
Spray Arm Replacement
Remove the lower rack, unscrew the spray arm retaining nut, lift out the old spray arm and replace with new one. Ensure proper alignment before tightening.
Heating Element Replacement
Disconnect power, remove lower spray arm and filter assembly. Disconnect wiring harness and mounting brackets. Install new element and reassemble.
Door Latch Installation
Remove inner door panel, disconnect electrical connections, remove mounting screws. Install new latch assembly and reassemble door components.
Water Inlet Valve
Turn off water supply, disconnect hoses and electrical connections. Remove mounting screws and replace valve. Check for leaks after installation.
Drain Pump Replacement
Remove lower access panel, disconnect drain hose and electrical connections. Remove mounting hardware and install new pump assembly.
Door Gasket/Seal
Carefully remove old gasket from door channel. Clean channel thoroughly. Install new gasket ensuring proper seating in channel around entire door.
Required Tools
Phillips Screwdriver
For removing access panels and components
Nut Driver Set
For spray arm and pump assembly removal
Pliers
For hose clamp and connection work
Multimeter
For electrical testing and verification
Putty Knife
For gasket removal and installation
Bucket & Towels
For water containment during repairs
Parts Troubleshooting
| Problem | Possible Part Failure | Solution |
|---|---|---|
| Dishwasher won't start | Door latch assembly, control board | Test door switch, replace latch assembly if faulty |
| Poor cleaning results | Spray arms, filter assembly, heating element | Clean or replace spray arms, check filter, test heating element |
| Water not draining | Drain pump, drain hose | Check drain pump operation, clear obstructions in hose |
| Leaking water | Door gasket, water inlet valve, tub seals | Inspect and replace door gasket, check valve connections |
| Unusual noises | Spray arms, wash pump, rack rollers | Check for obstructions in spray arms, inspect pump assembly |
| No heat during cycle | Heating element, thermal fuse, thermostat | Test heating element continuity, check thermal protection devices |
Error Codes Related to Parts
- E09: Water intake issue - Check water inlet valve and pressure switch
- E15: Drainage problem - Inspect drain pump and hose
- E22: Heating system fault - Test heating element and sensors
- E24: Water leakage detected - Check door seal and connections
- E25: Door switch error - Replace door latch assembly
- E32: Temperature sensor failure - Replace temperature sensor
Parts Ordering Information
Current Model Parts
SHX68T52UC/02
Complete Parts Catalog
SHX68T55UC
Similar Model Parts
SHX68T56UC
Premium Model Parts
SHX68T53UC
Basic Model Parts
Popular Replacement Kits
Filter Kit
Complete filter assembly
Spray Arm Kit
Upper & lower spray arms
Rack Repair Kit
Rack rollers and hardware
Seal Kit
Door and tub seals