Common Replacement Parts
Most Frequently Replaced Parts:
- Spray Arms (Upper and Lower)
- Dishwasher Filters
- Door Springs and Hinges
- Water Inlet Valves
- Drain Pumps
- Heating Elements
- Door Seals and Gaskets
- Control Panels
Bosch Original Parts Numbers
| Upper Spray Arm | 00611902 |
| Lower Spray Arm | 00644237 |
| Filter Assembly | 00645137 |
| Door Seal | 00611965 |
| Heating Element | 00645170 |
| Water Inlet Valve | 00611985 |
| Drain Pump | 00644270 |
| Door Hinge Set | 00611928 |
Important: Always use genuine Bosch parts to ensure optimal performance and maintain warranty coverage.
Technical Specifications
Parts Installation Guide
Tools Needed for Parts Replacement:
- Phillips screwdriver set
- Torx screwdriver set
- Pliers (needle nose and regular)
- Socket wrench set
- Multimeter
- Bucket and towels
Common Parts Replacement Procedures
- Spray Arm Replacement: Remove lower rack, unscrew spray arm retaining nut, lift off old spray arm, install new one ensuring proper alignment.
- Filter Replacement: Twist filter assembly counterclockwise to unlock, lift out, clean area, install new filter assembly and lock clockwise.
- Door Seal Installation: Remove old seal by pulling from groove, clean channel thoroughly, install new seal starting from top center working around edges.
- Heating Element Replacement: Disconnect power, remove lower spray arm and filter, disconnect wiring, remove mounting screws, install new element.
- Water Inlet Valve Replacement: Turn off water supply, disconnect hoses, remove mounting screws, disconnect electrical connections, install new valve.
Safety First: Always disconnect power and water supply before attempting any parts replacement. Consult professional if unsure.
Parts Troubleshooting
| Problem | Possible Faulty Part | Solution |
|---|---|---|
| Dishes not getting clean | Clogged spray arms, worn filters | Clean or replace spray arms and filters |
| Water not heating | Heating element, thermostat | Test and replace heating element or thermostat |
| Leaking from door | Door seal, hinge alignment | Replace door seal, adjust hinges |
| Not filling with water | Water inlet valve, float switch | Replace inlet valve or float switch |
| Not draining properly | Drain pump, drain hose | Clean or replace drain pump and check hose |
| Unusual noises | Spray arms, pump assembly | Check for obstructions, replace worn parts |
Error Codes Related to Parts
- E15: Water heating issue - Check heating element and thermostat
- E09: Water inlet problem - Check water inlet valve and water supply
- E02: Drainage issue - Check drain pump and drain hose
- E14: Water leakage detected - Check door seal and internal hoses
Parts Ordering Information
Bosch SHEM63W55N Specific Parts
Electrical Components
Note: For parts not listed here, please contact Bosch Customer Service or visit authorized Bosch parts dealers.